Preparation of La2O3 Slag Glass-Ceramics by Microwave Heating

Abstract

Abstract: Using slag to prepare slag glass-ceramics is one of the main ways to improve the utilization rate of mineral resources. CaO-MgO-Al₂O₃-SiO₂(CMAS) series pyroxene phase slag glass-ceramics were prepared using Bayan Obo tailings as raw materials by microwave one-step method. 835 ℃ was choosed as the crystallization temperature and the influence of microwave heating on the crystallization behavior and microstructure of glass-ceramics were studied. Effect of La₂O₃ addition on the crystallization behavior of slag glass-ceramics were discussed using La₂O₃ as the research variable. Compared with traditional heat treatment system, the microwave heating achieves higher crystallization effect in a shorter time. Here, the addition of La₂O₃ promotes grain refinement. According to the analysis of Raman spectroscopy, the addition of La ion will cause the increase of bridging oxygen in the glass network and increase the tightness and integrity of the crystal. The hardness is the highest when the addition of La is 4% (mass fraction), and the Vickers hardness reaches 829.22 MPa.

Key words: Bayan Obo tailing, microwave method, slag glass-ceramics, La₂O₃, Raman spectroscopy

CLC Number:

TQ171

ZHAO Guangkai, XU Wence, LIU Saiyu, ZHANG Yuxuan, WU Nannan, LIU Fang, OUYANG Shunli. Preparation of La₂O₃ Slag Glass-Ceramics by Microwave Heating[J]. JOURNAL OF SYNTHETIC CRYSTALS, 2021, 50(5): 920-926.

References

[1] 白淑英,朱倩文,沈渭寿,等.白云鄂博矿区生态退化研究[J].生态与农村环境学报,2016,32(3):367-373.
BAI S Y, ZHU Q W, SHEN W S, et al. Effect of mining on ecological degradation in Bayan Obo[J]. Journal of Ecology and Rural Environment, 2016, 32(3): 367-373(in Chinese).
[2] HATJE V, PEDREIRA R M A, DE REZENDE C E, et al. The environmental impacts of one of the largest tailing dam failures worldwide[J]. Scientific Reports, 2017, 7(1): 10706.
[3] NIU Y H, FAN X Y, REN D, et al. Effect of Na₂CO₃ content on thermal properties of foam-glass ceramics prepared from smelting slag[J]. Materials Chemistry and Physics, 2020, 256: 123610.
[4] CHEN K Y, LI Y, MENG X Y, et al. New integrated method to recover the TiO₂ component and prepare glass-ceramics from molten titanium-bearing blast furnace slag[J]. Ceramics International, 2019, 45(18): 24236-24243.
[5] ZHANG Z K, WANG J, LIU L N, et al. Preparation and characterization of glass-ceramics via co-sintering of coal fly ash and oil shale ash-derived amorphous slag[J]. Ceramics International, 2019, 45(16): 20058-20065.
[6] ZHANG H X, DU Y S, YANG X W, et al. Influence of rare earth ions on metal ions distribution and corrosion behavior of tailing-derived glass-ceramics[J]. Journal of Non-Crystalline Solids, 2018, 482: 105-115.
[7] GAO X Y, WANG H Y, WANG C M, et al. First-principles investigation of the effects of Re (La, Ce, Pr and Nd) doping on the diopside phase of glass-ceramics[J]. Journal of Non-Crystalline Solids, 2019, 526: 119701.
[8] BHONGALE S R, INGAWALE H R, SHINDE T J, et al. Effect of Nd³⁺ substitution on structural and magnetic properties of Mg-Cd ferrites synthesized by microwave sintering technique[J]. Journal of Rare Earths, 2018, 36(4): 390-397.
[9] MARIA JOSE S, MATHEW C T, K THOMAS J. Fabrication of Dysprosium doped Y₂O₃ infrared transparent ceramic materials by a microwave sintering technique[J]. Materials Today: Proceedings, 2020, 24: 2383-2393.
[10] WANG X X, LIU Z H, TANG Y H, et al. Low temperature and rapid microwave sintering of Na₃Zr₂Si₂PO₁₂ solid electrolytes for Na-ion batteries[J]. Journal of Power Sources, 2021, 481: 228924.
[11] DYATKIN B, GAMACHE R M, ROCK B Y, et al. Microwave-assisted pressureless sintering of silicon-reinforced boron carbide composites[J]. Journal of Solid State Chemistry, 2020, 292: 121659.
[12] LIU Y N, ZHU J Q, DAI B. Transparent MgAl₂O₄ ceramics prepared by microwave sintering and hot isostatic pressing[J]. Ceramics International, 2020, 46(16): 25738-25740.
[13] LI H X, LI B W, DENG L B, et al. Evidence for non-thermal microwave effect in processing of tailing-based glass-ceramics[J]. Journal of the European Ceramic Society, 2019, 39(4): 1389-1396.
[14] HAN Y J, JIA X L, LIU F, et al. Effect of Cr₂O₃ content on high-temperature dielectric properties and crystallisation of CMAS glass-ceramics[J]. Materials Research Express, 2019, 6(7): 075213.
[15] JIA H Y, ZHOU W C, NAN H Y, et al. Enhanced high temperature microwave absorption of La_0.9Sr_0.1MnO₃/MgAl₂O₄ composite ceramics based on controllable electrical conductivity[J]. Journal of the European Ceramic Society, 2020, 40(5): 1931-1937.
[16] HAO S Z, ZHOU D, HUSSAIN F, et al. Structure, spectral analysis and microwave dielectric properties of novel x(NaBi)_0.₅MoO₄-(1-x)Bi_2/3MoO₄ (x=0.2~0.8) ceramics with low sintering temperatures[J]. Journal of the European Ceramic Society, 2020, 40(10): 3569-3576.
[17] HRUBÝ A. Evaluation of glass-forming tendency by means of DTA[J]. Czechoslovak Journal of Physics B, 1972, 22(11): 1187-1193.
[18] LI H R, LIU S Y, XU W C, et al. The mechanism of the crystalline characteristics of spinel-induced epitaxial growth of diopside in CMAS glass-ceramics[J]. Journal of the European Ceramic Society, 2021, 41(2): 1603-1612.
[19] FURUKAWA T, WHITE W B. Raman spectroscopic investigation of sodium borosilicate glass structure[J]. Journal of Materials Science, 1981, 16(10): 2689-2700.
[20] LIU S Y, CHEN Y X, OUYANG S L, et al. Microstructural transformation of stainless steel slag-based CAMS glass ceramics prepared by SPS[J]. Ceramics International, 2021, 47(1): 1284-1293.
[21] 欧阳顺利,李保卫,张雪峰,等.含稀土元素的矿渣纳米晶玻璃陶瓷的光谱学研究[J].光谱学与光谱分析,2015,35(8):2316-2319.
OUYANG S L, LI B W, ZHANG X F, et al. Spectroscopic research on slag nanocrystal glass ceramics containing rare earth elements[J]. Spectroscopy and Spectral Analysis, 2015, 35(8): 2316-2319(in Chinese).
[22] 李保卫,欧阳顺利,张雪峰,等.温度对CaO-MgO-Al₂O₃-SiO₂系纳米晶玻璃陶瓷结构影响的拉曼光谱研究[J].光谱学与光谱分析,2014,34(7):1869-1872.
LI B W, OUYANG S L, ZHANG X F, et al. Effect of temperature on the structure of CaO-MgO-Al₂O₃-SiO₂ nanocrystalline glass-ceramics studied by Raman spectroscopy[J]. Spectroscopy and Spectral Analysis, 2014, 34(7): 1869-1872(in Chinese).

Preparation of La₂O₃ Slag Glass-Ceramics by Microwave Heating

PDF (PC)

Knowledge

Abstract

Cite this article

share this article

References

Related Articles 7

Recommended Articles

Metrics

Comments

[1]	. Preparation of CaO-MgO-Al2O3-SiO2 Glass Ceramics by Microwave Heating Treatment [J]. JOURNAL OF SYNTHETIC CRYSTALS, 2016, 45(9): 2227-2231.
[2]	DANG Li;NAI Xue-ying;DONG Ya-ping;LI Wu. Rapid Synthesis of Magnesium Oxysulfate Whisker by Microwave Method [J]. JOURNAL OF SYNTHETIC CRYSTALS, 2016, 45(1): 21-27.
[3]	DENG Lei-bo;ZHANG Xue-feng;LI Bao-wei;JIA Xiao-lin;ZHANG Ming-xing;OUYANG Shun-li;LI Hao. Influence of Crucible on the Microstructure and Properties of CaO-Al2O3-MgO-SiO2 Slag Glass-Ceramics [J]. JOURNAL OF SYNTHETIC CRYSTALS, 2015, 44(11): 3133-3139.
[4]	FAN Zhi-qin;LI Rui;CAI Gen-wang;ZHANG Jun-de;WANG Jian-xing. Effect of Discharge Process on Field Emission Properties of Carbon Nanotubes Film [J]. JOURNAL OF SYNTHETIC CRYSTALS, 2012, 41(4): 1102-1106.
[5]	. Effects of Discharge Power on Silicon-based Films Fabricated by VHF-PECVD [J]. JOURNAL OF SYNTHETIC CRYSTALS, 2004, 33(4): 662-666.
[6]	. Analysis of Residual Stress Distribution in DC Arc Plasma Jet CVD High Quality Diamond Films by Raman Spectroscopy [J]. JOURNAL OF SYNTHETIC CRYSTALS, 2004, 33(4): 674-678.
[7]	WEI Ai-xiang;CHEN Di-hu;ZHANG Hai-yan;TANG Xin-gui;ZHOU You-guo;YANG Zeng-hong. Raman Spectra and Surface Morphology of Nitrogen-doping Tetrahedral Amorphous Carbon Films [J]. JOURNAL OF SYNTHETIC CRYSTALS, 2000, 29(3): 240-244.