Mg2+对半水硫酸钙晶须结晶习性的影响

摘要/Abstract

摘要： 本文以磷石膏为原料蒸压制备半水硫酸钙晶须,采用数字显微镜、X射线衍射(XRD)和X射线光电子能谱(XPS)等微观测试方法对Mg²⁺作用下的半水硫酸钙晶须微观形貌、组成及晶面发育情况等进行试验研究,运用分子动力学技术模拟计算Mg²⁺在半水硫酸钙晶体晶面的相互作用能和径向分布函数,两者结合探讨Mg²⁺对半水硫酸钙晶体不同晶面结晶习性的影响。结果表明,Mg²⁺和半水硫酸钙晶体不同晶面的相互作用能从小到大顺序为:ΔE₍₂₀₀₎<ΔE₍₀₀₂₎<ΔE₍₄₀₀₎<ΔE₍₀₂₀₎<ΔE₍₂₀₄₎,即Mg²⁺主要吸附在半水硫酸钙晶体的(200)、(002)、(400)晶面上。Mg²⁺与SO^2-₄间的作用距离小于Ca²⁺与SO^2-₄间的作用距离,Mg与S之间产生了明显的电子效应,且电子效应随硫酸镁掺量的增加而增强,XRD衍射峰位置随硫酸镁掺量的增多向右偏移变得更加明显,说明有少量的Mg²⁺嵌入半水硫酸钙晶格。在硫酸镁掺量0.15%(质量分数,下同)时,优先促进晶体c轴方向的生长,使半水硫酸钙晶须呈细长针状,平均长度为47.29 μm,平均长径比为36.07;在硫酸镁掺量为0.30%时,抑制晶体沿c轴和径向的生长,使半水硫酸钙晶须呈细短针状,平均长度为39.72 μm,平均长径比为28.91。

关键词: 半水硫酸钙晶须, 磷石膏, Mg²⁺, 结晶习性, 分子动力学模拟

Abstract: In this paper, calcium sulfate hemihydrate whiskers were prepared by autoclaving using phosphogypsum as raw material. Digital microscope, X-ray diffraction (XRD) and X-ray photoelectron spectrometer (XPS) were used to investigate the microscopic morphology, composition and crystal surface development of calcium sulfate hemihydrate whiskers under the effect of Mg²⁺. Using molecular dynamics technology to simulate the interaction energy and radial distribution function of Mg²⁺ in the crystal surface of the calcium sulfate crystal. The effect of Mg²⁺ on the crystallization habits of calcium sulfate crystals was explored by combining the two techniques. The results show that the interaction energies of Mg²⁺ and different crystal faces of calcium sulfate hemihydrate crystals from smallest to largest are listed below: ΔE₍₂₀₀₎<ΔE₍₀₀₂₎<ΔE₍₄₀₀₎<ΔE₍₀₂₀₎<ΔE₍₂₀₄₎, which illustrates that Mg²⁺ is mainly adsorbed on the (200), (400) and (002) crystal faces of calcium sulfate hemihydrate crystals. The interaction distance between Mg²⁺ and SO^2-₄ is smaller than that between Ca²⁺ and SO^2-₄. There is an obvious electronic effect between Mg and S, and the electronic effect is enhanced with the increase of magnesium sulfate content. The position of XRD diffraction peak is more obvious to the right with the increase of magnesium sulfate. All indicate that a small amount of Mg²⁺is embedded in the crystal lattice of calcium sulfate hemihydrate. At 0.15% (mass fraction, the same as below) of magnesium sulfate content, the growth of c-axis direction was preferentially promoted, resulting in slender needle-like calcium sulfate hemihydrate whiskers with an average length of 47.29 μm and an average L/D ratio of 36.07. At 0.30% of magnesium sulfate content, the growth of c-axis and radial direction was inhibited, resulting in slender needle-like calcium sulfate hemihydrate whiskers with an average length of 39.72 μm and an average L/D ratio of 28.91.

Key words: calcium sulfate hemihydrate whisker, phosphogypsum, Mg²⁺, crystallization habit, molecular dynamics simulation

中图分类号:

TQ132.3⁺2

王青, 刁华利, 刘冬梅, 张典, 徐港. Mg²⁺对半水硫酸钙晶须结晶习性的影响[J]. 人工晶体学报, 2023, 52(10): 1897-1906.

WANG Qing, DIAO Huali, LIU Dongmei, ZHANG Dian, XU Gang. Effect of Mg²⁺ on Crystallization Habit of Calcium Sulfate Hemihydrate Whiskers[J]. JOURNAL OF SYNTHETIC CRYSTALS, 2023, 52(10): 1897-1906.

参考文献

[1] 侯江, 郭卫广, 雍毅, 等. 基于文献计量学方法剖析磷石膏研究及进展[J]. 磷肥与复肥, 2021, 36(1): 32-35.
HOU J, GUO W G, YONG Y, et al. Analysis of research and development of phosphogypsum based on bibliometric method[J]. Phosphate & Compound Fertilizer, 2021, 36(1): 32-35 (in Chinese).
[2] 郑绍聪, 朱丽苹, 谢刚, 等. 高纯天然石膏水热法制备硫酸钙晶须研究[J]. 无机盐工业, 2019, 51(7): 39-42.
ZHENG S C, ZHU L P, XIE G, et al. Experimental study on preparation of calcium sulfate whiskers from high purity natural gypsum with hydrothermal method[J]. Inorganic Chemicals Industry, 2019, 51(7): 39-42 (in Chinese).
[3] 梁现红, 谭琦, 张传祥, 等. 大长径比硫酸钙晶须的制备及形貌研究[J]. 矿产保护与利用, 2017(6): 87-92+96.
LIANG X H, TAN Q, ZHANG C X, et al. Study on the preparation and morphology of large aspect ratio calcium sulfate whisker[J]. Conservation and Utilization of Mineral Resources, 2017(6): 87-92+96 (in Chinese).
[4] 王艾文, 陈德玉, 黄滔. 磷石膏常压无氯盐溶液法制备硫酸钙晶须[J]. 非金属矿, 2020, 43(4): 84-87.
WANG A W, CHEN D Y, HUANG T. Preparation of calcium sulfate whiskers from phosphogypsum under atmospheric pressure in the chlorine-free salt solution[J]. Non-Metallic Mines, 2020, 43(4): 84-87 (in Chinese).
[5] MIAO M, FENG X, WANG G L, et al. Direct transformation of FGD gypsum to calcium sulfate hemihydrate whiskers: preparation, simulations, and process analysis[J]. Particuology, 2015, 19: 53-59.
[6] 王永钱, 马群, 原骜, 等. 电石渣制备硫酸钙晶须及影响因素研究[J]. 人工晶体学报, 2014, 43(12): 3284-3289.
WANG Y Q, MA Q, YUAN A, et al. Research on preparation of calcium sulfate whisker from carbide slag and influence factors[J]. Journal of Synthetic Crystals, 2014, 43(12): 3284-3289 (in Chinese).
[7] 王艾文. 磷石膏常压无氯盐溶液法制备硫酸钙晶须[D]. 绵阳: 西南科技大学, 2021.
WANG A W. Preparation of calcium sulfate whiskers from phosphogypsum by chlorine-free salt solution method at atmospheric pressure[D]. Mianyang: Southwest University of Science and Technology, 2021 (in Chinese).
[8] LIU C J, ZHAO Q, WANG Y G, et al. Hydrothermal synthesis of calcium sulfate whisker from flue gas desulfurization gypsum[J]. Chinese Journal of Chemical Engineering, 2016, 24(11): 1552-1560.
[9] 杨林, 周杰, 李贺军, 等. 晶形助长剂对磷石膏制硫酸钙晶须性能的影响[J]. 无机盐工业, 2012, 44(10): 41-43.
YANG L, ZHOU J, LI H J, et al. Influence of crystal growing agent on properties of calcium sulfate whisker with phosphogypsum[J]. Inorganic Chemicals Industry, 2012, 44(10): 41-43 (in Chinese).
[10] ZHANG X T, WANG X, JIN B, et al. Crystal structure formation of hemihydrate calcium sulfate whiskers (HH-CSWs) prepared using FGD gypsum[J]. Polyhedron, 2019, 173: 114140.
[11] FAN H, SONG X F, LIU T J, et al. Effect of Al³⁺ on crystal morphology and size of calcium sulfate hemihydrate: experimental and molecular dynamics simulation study[J]. Journal of Crystal Growth, 2018, 495: 29-36.
[12] TANG Y B, GAO J M. Investigation of the effects of sodium dicarboxylates on the crystal habit of calcium sulfate α-hemihydrate[J]. Langmuir, 2017, 33(38): 9637-9644.
[13] MAO X L, SONG X F, LU G M, et al. Control of crystal morphology and size of calcium sulfate whiskers in aqueous HCl solutions by additives: experimental and molecular dynamics simulation studies[J]. Industrial & Engineering Chemistry Research, 2015, 54(17): 4781-4787.
[14] XIN Y, HOU S C, XIANG L, et al. Adsorption and substitution effects of Mg on the growth of calcium sulfate hemihydrate: an ab initio DFT study[J]. Applied Surface Science, 2015, 357: 1552-1557.
[15] HOU S C, WANG J, WANG X X, et al. Effect of Mg²⁺ on hydrothermal formation of α-CaSO₄·0.5H₂O whiskers with high aspect ratios[J]. Langmuir, 2014, 30(32): 9804-9810.
[16] CHAKRABORTY T, HENS A, KULASHRESTHA S, et al. Calculation of diffusion coefficient of long chain molecules using molecular dynamics[J]. Physica E: Low-Dimensional Systems and Nanostructures, 2015, 69: 371-377.
[17] 师琳琳. 铀酰在钠蒙脱石(001)面上吸附行为的分子模拟[D]. 太原: 太原理工大学, 2015.
SHI L L. Molecular simulation of uranyl adsorption on(001)surfaces of Na-montmorillonite[D]. Taiyuan: Taiyuan University of Technology, 2015 (in Chinese).
[18] MAO X L, SONG X F, LU G M, et al. Effect of additives on the morphology of calcium sulfate hemihydrate: experimental and molecular dynamics simulation studies[J]. Chemical Engineering Journal, 2015, 278: 320-327.
[19] 栾扬. 基于仿真技术研究化学干预对磷建筑石膏转晶效果影响[D]. 昆明: 昆明理工大学, 2018.
LUAN Y. Research on effect of chemical intervention on crystal transformation of phosphogypsum crystals according to simulation technology[D]. Kunming: Kunming University of Science and Technology, 2018 (in Chinese).
[20] 任华. 分子模拟在界面相互作用计算中的应用[D]. 西安: 西北工业大学, 2007.
REN H. The application of molecular simulation in the calculation of interfacial interaction[D]. Xi'an: Northwestern Polytechnical University, 2007 (in Chinese).
[21] MAO X L, SONG X F, LU G M, et al. Effects of metal ions on crystal morphology and size of calcium sulfate whiskers in aqueous HCl solutions[J]. Industrial & Engineering Chemistry Research, 2014, 53(45): 17625-17635.
[22] LIU D M, WANG Q, XU G, et al. Effect of modifiers on crystalizing habit and mechanical strength of α-hemihydrate gypsum prepared from PG by an autoclaved method[J]. Construction and Building Materials, 2023, 366: 130114.
[23] 郝海青, 袁致涛, 李丽匣, 等. 油酸钠控制硫酸钙晶须晶面生长的机理研究[J]. 无机材料学报, 2016, 31(11): 1184-1190.
HAO H Q, YUAN Z T, LI L X, et al. Mechanism of faces growth in preparing calcium sulphate whiskers using sodium oleate[J]. Journal of Inorganic Materials, 2016, 31(11): 1184-1190 (in Chinese).
[24] 刘冬梅, 张典, 彭艳周, 等. 柠檬酸钠对半水石膏不同晶面结晶习性及力学性能的影响[J]. 材料导报, 2021, 35(18): 18052-18058.
LIU D M, ZHANG D, PENG Y Z, et al. Effect of sodium citrate on crystal habit and mechanical properties of different crystal surfaces of hemihydrate gypsum[J]. Materials Reports, 2021, 35(18): 18052-18058 (in Chinese).
[25] GAO D J, ZHANG D, PENG Y Z, et al. Effects of different carboxyl additives on the growth habits of hemihydrate gypsum crystals[J]. Construction and Building Materials, 2022, 316: 126037.
[26] 王力, 马继红, 郭增维, 等. 水热法制备硫酸钙晶须及其结晶形态的研究[J]. 材料科学与工艺, 2006, 14(6): 626-629.
WANG L, MA J H, GUO Z W, et al. Study on the preparation and morphology of calcium sulfate whisker by hydrothermal synthesis method[J]. Materials Science and Technology, 2006, 14(6): 626-629 (in Chinese).
[27] 邓志银, 袁义义, 孙骏, 等. 脱硫石膏制备硫酸钙晶须的影响因素研究[J]. 粉煤灰, 2009, 21(6): 25-27.
DENG Z Y, YUAN Y Y, SUN J, et al. Research on affecting factor of preparation of calcium sulfate whisker with FGD gypsum[J]. Coal Ash, 2009, 21(6): 25-27 (in Chinese).
[28] WANG B Q, YANG L, CAO J X. The influence of impurities on the dehydration and conversion process of calcium sulfate dihydrate to α-calcium sulfate hemihydrate in the two-step wet-process phosphoric acid production[J]. ACS Sustainable Chemistry & Engineering, 2021, 9(43): 14365-14374.
[29] LIU T J, FAN H, XU Y X, et al. Effects of metal ions on the morphology of calcium sulfate hemihydrate whiskers by hydrothermal method[J]. Frontiers of Chemical Science and Engineering, 2017, 11(4): 545-553.
[30] 汪潇, 金彪, 张小婷, 等. MgSO₄/MgCl₂对脱硫石膏溶解度及其晶须结晶的影响[J]. 河南科技大学学报(自然科学版), 2018, 39(2): 6-10+24+4.
WANG X, JIN B, ZHANG X T, et al. Effects of MgSO₄/MgCl₂ on FGD gypsum solubility and whisker crystallization[J]. Journal of Henan University of Science and Technology (Natural Science), 2018, 39(2): 6-10+24+4 (in Chinese).
[31] GUAN Q J, SUN W, HU Y H, et al. A facile method of transforming FGD gypsum to α-CaSO₄·0.5H₂O whiskers with cetyltrimethylammonium bromide (CTAB) and KCl in glycerol-water solution[J]. Scientific Reports, 2017, 7: 7085.
[32] 张旭昀, 康庆鑫, 汪洋, 等. 硫酸钙成垢过程形貌预测与分子动力学模拟[J]. 化工机械, 2018, 45(4): 521-524.
ZHANG X Y, KANG Q X, WANG Y, et al. Morphology prediction and molecular dynamics simulation of scale formation of calcium sulfate[J]. Chemical Engineering & Machinery, 2018, 45(4): 521-524 (in Chinese).

Mg²⁺对半水硫酸钙晶须结晶习性的影响

Effect of Mg²⁺ on Crystallization Habit of Calcium Sulfate Hemihydrate Whiskers

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价

[1]	杨红艳, 欧阳俊瑶, 夏蝶, 顾雪梅, 杨姗, 王伟. 添加CaSO₄·2H₂O为晶种制备磷石膏半水硫酸钙晶须[J]. 人工晶体学报, 2022, 51(2): 309-315.
[2]	耿邦杰;左然. 硅晶体生长固液界面形貌研究[J]. 人工晶体学报, 2020, 49(5): 804-810.
[3]	谢晴;蒋美雪;彭同江;国佳豪. 磷石膏常压酸化法制备无水硫酸钙晶须的实验研究[J]. 人工晶体学报, 2019, 48(6): 1060-1066.
[4]	羊道和;杨玉荣;易美桂. 柠檬酸对半水硫酸钙晶须形貌稳定性影响[J]. 人工晶体学报, 2019, 48(1): 95-100.
[5]	陈畅;史思涛;伍勇华;郭政;李国新;苏明周;王会萌. 常温改性半水硫酸钙晶须及其稳定化机理研究[J]. 人工晶体学报, 2018, 47(4): 695-702.
[6]	林艳;彭同江;孙红娟;蒋关雪;丁文金;罗东山. 磷石膏在醋酸铵溶液中的溶解量及滤渣产物的变化[J]. 人工晶体学报, 2018, 47(3): 598-605.
[7]	任继齐;常新安;陈学安;肖卫强;张明荣. 反式二苯乙烯(TSB)的溶液法晶体生长[J]. 人工晶体学报, 2017, 46(3): 404-409.
[8]	周熠;程宏飞;杜贝贝;张帅;刘钦甫. 高岭石/二甲基亚砜插层复合物结构模拟[J]. 人工晶体学报, 2017, 46(1): 26-32.
[9]	耿庆钰;李建锡;韩伟明;李楠;郑书瑞. 磷石膏蒸压制备半水硫酸钙晶须[J]. 人工晶体学报, 2016, 45(7): 1892-1897.
[10]	王宝川;彭同江;杨梦娜;林艳. 溶液中杂质离子对石膏晶须生长的影响[J]. 人工晶体学报, 2016, 45(6): 1560-1566.
[11]	禹鹤;汤建伟;王保明;化全县;芦雷鸣;刘咏. 基于响应面法的半水硫酸钙晶须制备工艺优化[J]. 人工晶体学报, 2016, 45(2): 447-453.
[12]	周耐根;张弛;刘博;李克;周浪. 硅晶体生长速率与过冷度关系的分子动力学模拟研究[J]. 人工晶体学报, 2016, 45(1): 28-34.
[13]	何玉龙;陈德玉;蔡攀;张涛;王舒州. 晶形控制剂对α半水石膏结晶形态的调控研究[J]. 人工晶体学报, 2016, 45(1): 192-199.
[14]	杨林;曹建新;刘亚明. 半水磷石膏的晶型、形貌及胶凝性能的影响因素研究[J]. 人工晶体学报, 2015, 44(9): 2460-2467.
[15]	何小玲;周海涛;王金亮;霍汉德;张昌龙;左艳彬;卢福华. Bi4Si3O12晶体的水热法生长研究[J]. 人工晶体学报, 2015, 44(6): 1475-1479.